摻鋁氧化鋅薄膜的光學性能研究

摻鋁氧化鋅薄膜的光學性能研究
 
摘要:摻鋁氧化鋅（ZAO）是1種備受關注的新型透明導電薄膜材料。它的很多優點顯示，它是替代目前應用廣泛的In2O3∶Sn(ITO)薄膜的最佳薄膜材料。與In2O3∶Sn（ITO）薄膜相比，ZAO薄膜具有原材料的自然界儲量豐富、易于制造、成本低廉、無毒、熱穩定性和化學穩定性好等優點，因此，其必將成為新1代透明導電氧化物薄膜的代表。我們采用直流磁控濺射制備技術進行ZAO薄膜的制備實驗。用原子力顯微鏡、臺階儀、紫外-可見分光光度計、橢偏儀等測試手段對制備的樣品進行組織結構、光學分析。
從大量的制備ZAO薄膜實驗數據中，分析直流磁控濺射制備工藝參數對ZAO薄膜性能的影響，總結出最佳制備工藝參數: 靶基距為7cm，沉積工作壓強保持為0.5Pa,然后調節氧氬分壓比為1%，加熱玻璃基片到200 oC，以150W左右的濺射功率進行直流反應磁控濺射15min左右，最后在真空環境中退火處理1小時，退火溫度為200oC。在最佳工藝條件下制備出的ZAO薄膜的主要性能為:膜厚在600nm左右，可見光區平均透射率為89.2%，光學性能能滿足使用的需求。
本論文主要從薄膜的結構、光學特性變化的機理入手，為進1步全面研究ZAO薄膜的制備、結構特性、光學特性打下了堅實的基礎，也對ZAO薄膜的實際應用具有積極意義。
關鍵詞：ZAO薄膜，直流磁控濺射，可見光透射率，光學性能

The Al-doped ZnO(ZAO) thin film optical properties research
 
Abstract : Aluminum-doped zinc oxide (ZAO) is a new area of concern transparent conductive film. Its many advantages, it is a replacement of the current widespread use of In2O3∶Sn (ITO) films the best film material. And In2O3∶Sn (ITO) film, the film is ZAO raw materials rich in natural reserves, easy to manufacture, low-cost, nontoxic, thermal stability and good chemical stability advantages, therefore, will be the next generation of its transparent conductive oxide films representatives. We dc magnetron sputtering technique ZAO Films Preparation. Atomic force microscope, level sensor, UV-VIS spectrophotometer, ellipsometer, and other means of testing the sample preparation organizational structure, Optical analysis. Preparation from a large number of experimental data ZAO films, Analysis of DC magnetron sputtering process parameters on the performance of ZAO films, summed up best Preparation of parameters : target-substrate distance of 7 cm, sedimentary work to maintain the pressure for 0.5 Pa, and then adjusted partial pressure of oxygen and argon ratio of 1%. glass substrate heating to200oC. to about 150 W power for the sputtering DC reactive magnetron sputtering about 15 min. Finally in a vacuum environment annealing an hour, annealing temperature of200oC. In optimum conditions produced a film ZAO the main properties : 600 nm in thickness around, visible average transmission rate of 89.2%, optical properties can satisfy the demand. This paper mainly from the films structure, changes in the optical properties of the mechanism for further comprehensive study of ZAO Films Preparation, structural properties, optical properties lay a solid foundation for ZAO Films practical application of positive significance.
 Keywords  : ZAO film, DC magnetron sputtering, visible light transmittance, optical properties
..........................

【摻鋁氧化鋅薄膜的光學性能研究】相關文章：

硅薄膜的制備及光學性能研究03-01

化學浴沉積ZnSe薄膜及其光學特性研究03-07

軟件性能測試研究03-28

BT網絡(luò )性能的研究與改進11-22

再生高性能混凝土抗碳化性能試驗研究03-17

分集合并的性能研究與仿真03-07

基于LAPS的銅離子薄膜傳感器研究03-07

溶膠凝膠法制備摻銻二氧化錫薄膜的光電特性和表面形貌03-07

超硬材料薄膜涂層研究進展及應用12-20